Weber Performer Touch-N-Go Ignition Owner's Manual

WEBERWEBEROwner’s ManualTOUCH-N-GO™IGNITIONWARNING: Do not try to light thisappliance without reading "Lighting"instructions section of thi

10Assembly InstructionsWEBERWEBERFigure 1Step 1Assemble wheelsYou will need: axle, two wheel hubcaps, two wheels, wheel frame, hammerand a block of wo

11Step 2 (cont.)- Once the One Touch Handle is through the handleslot of the Ash Catcher Ring, tilt the ring back downand position the locking clips o

12Figure 3(a)Tab on the insideof frame tubeFigure 4Weber nameplate facing outStep 3Assemble the frameYou will need: top frame assembly, wheel frameass

13Figure 5Step 5Complete frame assemblyYou will need: two bottom connectors, tank holderassembly, four 1 3/4 inch bolts, four nylon washers and a7/16

14Figure 7Step 7Install bowl assemblyYou will need: bowl assembly, four 1 3/4 inch bolts, eightnylon washers, four aluminum washers, four acorn nuts,7

15Step 9Fill LP tankNote - The LP tank manufacturer is responsible for the materials, workmanship and performance of the tank.If the tank has a defect

16Figure 10The hose and regulator are connected in the followingmanner:Slide back the collar of the quick disconnect on the tankvalve. Figure 10 (a).

17If bubbles occur, or if a bubble enlarges, the connectionis leaking. Turn OFF the gas at LP tank.If the leak is at connection a) DO NOT OPERATE THEB

18(a)(b)Figure 14Note: Before sliding the CharBin into place check thatthe Cooking grate holder is sitting loosely on the framebrace and is conforming

19Figure 16Step 14Add grates, Char-Basket Fuel Holders and lidYou will need: charcoal grate, Char-Baskets, hingedcooking grate and lid.Place charcoal

2WARNINGS Do not store a spare or disconnected LP tank under or near this barbecue. Improper assembly may be dangerous. Please follow the assembly

204) Position filled Char-Baskets over burner. Figure 3.LightingOperating InstructionsDANGEROpen lid before lighting. Do not use anyflammable liquids

21Manual LightingWARNING: Do not attempt to light manuallywithout using the match holder.1) Open lid.2) Open bottom bowl vents.3) Move Char-Baskets

22Cooking MethodsDirect MethodFor foods requiring fewer than 30 minutes of cookingtime, cook directly over the coals, absorbing the full heat.1. Place

23Periodic Cleaning To remove ashes from the bowl, move control rod side toside so damper blades sweep ashes through the bowlvents and into the ash ca

24Check the following connections, as shown in figure 11:a) Test valve to regulator connection.b) Quick disconnect fitting to LP tank connection.If bu

25Safe handling tips for LP Gas Liquid Propane (LP) gas is a petroleum product asare gasoline and natural gas. LP gas is a gas atregular temperatures

26TroubleshootingProblemBurner burns with a yellow ororange flame, in conjunctionwith the smell of gas.Burner does not light, or flameis low.Burner fl

27MaintenanceAfter a period of nonuse we recommend that you perform the following maintenance procedures for yoursafety. Check hose before each use o

28BURNER FLAME PATTERNThe burner has been factory set for the correct air andgas mixture. The correct flame pattern is shown in Figure17. If the flame

3Weber Stephen Products Co. (Weber) hereby warrants tothe ORIGINAL RETAIL PURCHASER of this WeberBarbecue that if it is assembled and operated inaccor

4ContentsWARNINGS 2Warranty & Patents 3General Instructions 5Parts Listing 6-7Tools Needed 8-9Assembly 10-19Operating InstructionsLighting 20-21In

5General InstructionsYour Weber Performer Grill with Touch-N-Go Gas Ignitionis a portable outdoor cooking appliance. You can grill,barbecue, roast and

612331323334353637383142434445474649485051541415574567891011121314151617184119204182115452223242526,152827293039, 14-1540-4152535955565860

71. 1/4-20 x 5/8 inch truss head screw 2. Nylon damper handle 3. Lid damper4. 1/4 inch aluminum washer (9) 5. 1/4-20 acorn nut (4)6. Lid assembly 7. 2

8Check package contentsThe following item will be found in the top box.Bottom rackThe following items will be found in the large box(shipper).CharBin

9Charcoal grate Hinged cooking grate Burner cleaning tool/ match holder Two wheelsAxleAsh Catcher RingThe following items will be found in the hardwar