Weber GENESIS 3000 LX Owner's Manual

Serial NumberPlease use this number in registering your warrantyand any correspondence with the factory.WEBERWEBERGENESIS®3000 LXNatural Gas BarbecueO

10Step 2Assemble wheelsYou will need: axle, two wheel hubcaps, two wheels,wheel frame, hammer and a block of wood.Place one end of the axle on the blo

Step 4Continue frame assemblyYou will need: frame assembly, wheel frame assembly,front panel, caster frame, four 1/4-20 x 1/2 inch bolts, fournylon wa

12Step 7Install side burner locksNote: The locks are taped to the inside of the sideburner lid.You will need: frame assembly, two side burner locks an

13Burner tubesFigure 7Frame braceFrame crosspieceSpacerbracketKeps nutBoltNylonwasherTabStep 8Add cooking boxYou will need: frame assembly, cooking bo

14Step 9Install gas supplyGeneral Specifications for PipingNote - Contact your local municipality for buildingcodes regulating outdoor gas barbecue in

15Step 10Install igniterNote - The igniter wires are already attached to the GasCatcher Ignition Chamber and the igniter. This was done tofactory test

16Step 13Install side burnerYou will need: side burner assembly, burner grate,manifold bracket, and an adjustable wrench.WARNING: Make sure gas suppl

17Step 15Check for gas leaksTo perform leak checks: Slide back the collar of the quickdisconnect. Push male fitting of the hose into the quickdisconne

18Check:a) Hose to manifold connection. Figure 18 (a).b) Manifold to side burner hose connection.Figure 18 (b).WARNING: If there is a leak at connec

19Step 18Install the lidYou will need: lid, two hinge pins and two hair pin cotters.Set the lid in place. Align the hinges at the rear of thebarbecue.

2DANGERFailure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manualmay result in serious bodily injury or death, or in a fir

20Step 19Install tool holders, control panel and burnercontrol knobsYou will need: three tool holders, control panel, twoPhillips screws/washers, a Ph

21Slot in frame(view from below)Insert one end of the hinge rod into the hole in the frame.Figure 28 (a).Insert the other end into the hole in the swi

22Step 22Complete accessory installationYou will need: work table, two accessory trays, Warm-UpBasket, warming rack, thermometer, three tubing plugs a

23LightingSummary lighting instructions are on the control panel.1623457Figure 1Crossover Ignition System1) Open the lid. Figure 1.2) Make sure all bu

2424Manual Lighting1624573Figure 2Manual Lighting DANGERFailure to open lid while igniting thebarbecue, or not waiting 5 minutes toallow the gas to c

2525Lighting the side burnerThe side burner has a separate ignition system from themain cooking box.5241Figure 3 DANGERFailure to open lid while igni

2626CookingWARNING: Do not move the Weber Gas Barbecuewhen operating or hot.You can adjust the FRONT, CENTER and BACK burnersas desired. The control

272727WARNING: If there is a leak at connection a,retighten the fitting with a wrench and recheck forleaks with soap and water solution.If a leak per

General MaintenanceWeber Spider Stopper GuardsYour Weber Genesis Gas Barbecue, as well as anyoutdoor gas appliance, is a target for spiders and otheri

g) Lift and twist the burner assembly slightly, to separatethe crossover tube from the burners. Figure 14.Remove the burners from the cooking box.29Cr

3Weber-Stephen Products Co. (Weber) herebywarrants to the ORIGINAL PURCHASER of thisWeber Gas Barbecue that it will be free ofdefects in material and

3030Crossover Ignition System OperationsIf the Crossover Ignition System fails to ignite the Frontburner, light the Front burner with a match. If the

31ProblemBurners burn with a yellow or orange flame, inconjunction with the smell of gas.Burner does not light, or flame is low in HIGH position.Exper

32ProblemSide burner does not light.Flame is low in HIGH position.Flame is very yellow in conjunction withthe smell of gas,ORBurner makes popping nois

33

®®®®®®®®WEBERWEBER124567891011121315-161120252427 28 29 30313256-6055625442534947464544414239383736351422-23334051-52,4834502648433211718-19, 16613434

1 Lid (assembly)2 Lid handle 3 Warm-Up Basket4 Warming rack 5 Short Flavorizer Bars (8) 6 Long Flavorizer Bars (5) 7 Cooking grates (2) 8 Work table9

A FINAL WORDOFTHANKShank you for choosing a Weber Barbecue.Our family here at Weber has worked hardto produce the highest quality products for your sa

© 1997 Weber. Weber, , Genesis, Flavorizer and Crossover areregistered U.S. trademarks; Perma-Mount, Gas Catcher,FlameCheck, Steam-N-Chips, Spider

5ContentsWARNINGS... 2Warranty & Patents...

6General InstructionsYour Weber Gas Barbecue is a portable outdoor cookingappliance. With the Weber Gas Barbecue you can grill,barbecue, roast and bak

Step 1Check package contentsCooking box (assembly)Lid (assembly)HoseBottom trayWork tableTwo accessory traysSwing table7AssemblyTools neededScrewdrive

Control panelFront panelLeft frameWheel frameTwo frame connectorsFive long Flavorizer BarsEight short Flavorizer BarsTwo wheelsTwo aluminum drip pansC

Two wheel hubcaps(actual size)Two hinge pins(hardware size: 1/4 x 1 1/2 inch clevis pin)(actual size)Five 1/4-20 x 2 inch bolts(actual size)Six 1/4-20