WEBERWEBERWARNING: Do not try to light this appliancewithout reading "Lighting" instructionssection of this manual.THIS GAS APPLIANCE IS DES
10Figure 1Step 2Assemble wheelsYou will need: axle, two wheel hubcaps, two wheels,wheel frame, hammer and a block of wood.Place one end of the axle on
11Figure 3Step 4Continue frame assemblyYou will need: caster frame, wheel frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wren
12Figure 6Step 7Add front panelYou will need: front panel and two plastic buttons.Turn frame assembly right side up.Align the panel with the holes in
13Your Weber Gas Barbecue burner assembly has beenfactory assembled, pressure and flame tested. As a safetyprecaution we recommend you check the burne
14Frame braceManifold bracketFigure 10Step 9Install manifold bracketYou will need: manifold bracketHook the bracket onto the manifold at the center bu
15Step 11Add fuel scale assemblyYou will need: fuel scale assembly, two 1/4-20 wing nutsand two nylon washers.Slip the bolts on the back of the fuel s
16Step 13Set LP fuel scaleYou will need: LP tank (empty).Note - For accuracy, the fuel scale must be set with anempty tank.We utilize various LP tank
17Figure 16Step 15Check that all burner valves are offYou will need: one burner control knob.Valves are shipped in the OFF position, but you shouldche
18Step 17Check for gas leaksFigure 19 DANGERDo not use an open flame to check for gasleaks. Be sure there are no sparks or openflames in the area whi
19Step 19Install the bottom trayYou will need: bottom tray, catch pan holder, catch pan andone drip pan.Figure 24Figure 23Figure 25Bottom trayFinger g
2 DANGERFailure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manualmay result in serious bodily injury or death, or in a fi
20Step 20Install LidYou will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of thebarbecue. In
21Slot in frame(view from below)Insert one end of the hinge rod into the hole in the frame.Figure 29 (a).Insert the other end into the hole in the swi
22Step 23Complete accessory installationYou will need: Warm-Up Basket, warming rack, worktable, accessory trays, three tubing plugs, thermometerand a
23LightingSummary lighting instructions are on the control panel.13864527Figure 1Crossover Ignition SystemWARNING: The burner control knobs must be
24Manual Lighting 4) Turn the tank on by turning the tank valvecounterclockwise. 5) Strike a match and put the flame into the matchlighthole in the fr
25CookingWARNING: Do not move the Weber Gas Barbecuewhen operating or hot.You can adjust the FRONT, CENTER and BACK burners asdesired. The control se
26Periodic CleaningWARNING: Turn your Weber Gas Barbecue OFF andwait for it to cool before cleaning.CAUTION: Do not clean your Flavorizer Bars orcoo
27Cast Iron Cooking GratesWARNING: Follow all safety instructions providedwith your barbecue. Do not drop cast iron grates, theywill break. Prior to
2828Scale setting wing nutTank lockwing nutTank valveCollar(a)(b)Figure 3Refilling the LP tankWe recommend that you refill before the scale indicatorr
2929c) Connect the hose to the tank. Route the hose so itdoes not interfere with the scale indicator rod. Slideback the collar of the quick disconnect
3Weber-Stephen Products Co. (Weber) herebywarrants to the ORIGINAL PURCHASER of thisWeber Gas Barbecue that it will be free ofdefects in material and
303030Safe handling tips for LP Gas Liquid Propane (LP) gas is a petroleum product as aregasoline and natural gas. LP gas is a gas at regulartemperat
3131c) Valves to manifold connections. Figure 8 (c).d) The hose to regulator connection. Figure 8 (d).WARNING: If there is a leak at connection (b),
3232General MaintenanceWeber Spider Stopper GuardsYour Weber Gas Barbecue, as well as any outdoor gasappliance, is a target for spiders and other inse
h) To reinstall the burners, reverse steps c) through g).Caution: The burner openings must be positionedproperly over the valve orifices. Figure 18 (a
34Crossover Ignition System OperationsIf the Crossover Ignition System fails to ignite the Frontburner, light the Front burner with a match. If the Fr
3535ProblemBurners burn with a yellow or orange flame, in conjunction with the smell of gas.Burners do not light. -or-Burners have a small flickering
36WEBERWEBER®®®®®®®®12367810913-1422231528 303132343536376456-60615452515049484645444342414062-63555329243839471112162110-1454272625 3320651718-19, 11
37371 Lid (assembly)2 Lid handle3 Warm-Up Basket4 Warming rack 5 Short Flavorizer bars (8)6 Long Flavorizer bars (5)7 Cast iron sear grates (2)8 Work
© 1997 Weber. Weber, , Flavorizer and Crossover are registeredU.S. trademarks; Perma-Mount, Gas Catcher, FlameCheck,Steam-N-Chips, Spider Stopper,
A FINAL WORDOFTHANKShank you for choosing a Weber Barbecue.Our family here at Weber has worked hardto produce the highest quality products for your sa
5ContentsWARNINGS... 2Warranty & Patents...
6General InstructionsYour Weber Gas Barbecue is a portable outdoor cookingappliance. With the Weber Gas Barbecue you can grill,barbecue, roast and bak
7Step 1Check package contentsCooking box (assembly)Lid (assembly)LP tank LP tank filler adapterBottom trayTwo cooking gratesControl panelAssemblyTools
Left frameRight frameWheel frameCaster frameTwo frame connectorsWork tableSwing table assemblyLeft hand slide bar(assembly)Two Accessory traysAxleWarm
Six 1/4-20 x 1/2 inch bolts(actual size)1/4-20 hex nut(actual size)Two plastic buttons(actual size)1/4-20 keps nutTwo 1/4-20 wing nuts(actual size)Eig
Comments to this Manuals