Weber Genesis 2000 Series User Manual Page 1

Serial NumberPlease use this number in registering your warrantyand any correspondence with the factory.WEBERWEBERGENESIS®2000 SeriesLP Gas BarbecueOw

10Step 2Assemble wheelsYou will need: axle, two wheel hubcaps, two wheels,wheel frame, hammer and a block of wood.Place one end of the axle on the blo

11Step 4Continue frame assemblyYou will need: frame assembly, wheel frame assembly,front panel, caster frame, four 1/4-20 x 1/2 inch bolts, fournylon

12Burner tubesFigure 6Frame braceStep 7Add cooking boxYou will need: frame assembly, cooking box assembly,1/4-20 x 2 inch bolt, 1/4 inch nylon washer,

13Step 9Install tank panel assemblyYou will need: tank panel assembly, 1 1/4 inch bolt, 1/4-20 hex nut, 1/4 inch nylon washer and a 7/16 inchwrench.In

14Step 11Install igniterNote - The igniter wires are already attached to the GasCatcher Ignition Chamber and the igniter. This was done tofactory test

15Step 12Set LP fuel scaleYou will need: LP tank (empty).Note - For accuracy, the fuel scale must be set with anempty tank.We utilize various LP tank

16Route the hose so it will not interfere with the scaleindicator rod.The hose and regulator are connected in the followingmanner:Slide back the colla

17Step 16Check for gas leaks DANGERDo not use an open flame to check for gasleaks. Be sure there are no sparks or openflames in the area while you ch

18Step 17Install Flavorizer Bars and Cooking GratesYou will need: five long Flavorizer Bars, eight shortFlavorizer Bars and two cooking grates.Set th

19Step 19Install the lidYou will need: lid, two hinge pins and two hair pin cotters.Set the lid in place from the rear of the barbecue. Close andalign

2DANGERFailure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manualmay result in serious bodily injury or death, or in a fir

20Slot in frame(view from below)Insert one end of the hinge rod into the hole in the frame.Figure 27 (a).Insert the other end into the hole in the swi

21Position slide bar assembly on the outside of the casterframe. Put a nylon washer on each 1 3/4 inch screw, insertscrews through frame and slide bar

22LightingSummary lighting instructions are on the control panel.21734568Figure 1Crossover Ignition SystemWARNING: The burner control knobs must be i

234) Turn the tank on by turning the tank valvecounterclockwise. 5) Strike a match and put the flame into the matchlighthole in the front of the cooki

24CookingWARNING: Do not move the Weber Gas Barbecuewhen operating or hot.You can adjust the FRONT, CENTER and BACK burnersas desired. The control se

25Scale setting wing nutTank lockwing nutTank valveCollar(a)(b)Figure 3Refilling the LP tankWe recommend that you refill before the scale indicatorrea

26c) Connect the hose to the tank. Route the hose so itdoes not interfere with the scale indicator rod. Slideback the collar of the quick disconnect o

27Safe handling tips for LP Gas Liquid Propane (LP) gas is a petroleum product as aregasoline and natural gas. LP gas is a gas at regulartemperatures

28Check:a) Hose to manifold connections. Figure 8 (a).b) Regulator to tank connection. Figure 8 (b). WARNING: If there is a leak at connection (a),re

29General MaintenanceWeber Spider Stopper GuardsYour Weber Gas Barbecue, as well as any outdoor gasappliance, is a target for spiders and other insect

3Weber-Stephen Products Co. (Weber) herebywarrants to the ORIGINAL PURCHASER of thisWeber Gas Barbecue that it will be free ofdefects in material and

30g) Lift and twist the burner assembly slightly, to separatethe crossover tube from the burners. Figure 17.Remove the burners from the cooking box.Cr

31Crossover Ignition System OperationsIf the Crossover Ignition System fails to ignite the Frontburner, light the Front burner with a match. If the Fr

32ProblemBurners burn with a yellow or orange flame, in conjunction with the smell of gas.Burners do not light. -or-Burners have a small flickering fl

34®®®®®®®®WEBERWEBER1245678910-11131415, 11222426 27 28 29 30 31 326462-63565585351504948474544434241403954113311383452462512231617-18, 11201910366576

351 Lid (assembly)2 Lid handle 3 Warm-Up Basket4 Warming rack 5 Short Flavorizer Bars (8) 6 Long Flavorizer Bars (5) 7 Cooking grates (2) 8 Work table

A FINAL WORDOFTHANKShank you for choosing a Weber Barbecue.Our family here at Weber has worked hardto produce the highest quality products for your sa

© 1997 Weber. Weber, , Genesis, Flavorizer and Crossover areregistered U.S. trademarks; Perma-Mount, Gas Catcher,FlameCheck, Steam-N-Chips, Spider

5ContentsWARNINGS... 2Warranty & Patents...

6General InstructionsYour Weber Gas Barbecue is a portable outdoor cookingappliance. With the Weber Gas Barbecue you can grill,barbecue, roast and bak

Step 1Check package contentsCooking box (assembly)Lid (assembly)LP tank LP tank filler adapterBottom trayTwo work tablesTwo accessory traysSwing table

Control panelFront panelLeft frameWheel frameTwo frame connectorsTank panel assemblyFive long Flavorizer BarsEight short Flavorizer BarsTwo wheelsTwo

Two 10-24 x 1 3/4 machine screws(actual size)Two 10-24 hex nuts(actual size)Eighteen 1/4 inch nylon washers(actual size)1/4-20 keps nut1/4-20 x 1 1/4