43165 US 01/30/07LP GAS GRILL Built-In LP Gas Grill Installation Guide#43165S-440S-640YOU MUST READ THIS OWNER’S GUIDE BEFORE OPERATING YOUR GAS GRILL
10WWW.WEBER.COM® CAUTION: Use two people to lift and install the Summit® Built-In frame assembly.A.) Lift the frame assembly into the “island” struc
11WWW.WEBER.COM®11910C.(1)S440S640C.) Apply a bead of silicone sealant (1) around the perimeter and front edges of the grill that are in contact wit
12WWW.WEBER.COM®F)'#S44011(1) (3) (2) 12ASSEMBLY
13WWW.WEBER.COM®13S640S4401314(1)(2)S640S440ASSEMBLY
14WWW.WEBER.COM®S640S440abc15Match HolderASSEMBLY
15WWW.WEBER.COM®15S640S44016171/4” (6.35 mm) Drill BitASSEMBLY
16WWW.WEBER.COM®S640S440181920S440 S640S640S440ASSEMBLY
17WWW.WEBER.COM®17ASSEMBLY21S640S440
18WWW.WEBER.COM®(1)(2)(3)22S-440S-640ASSEMBLY
19WWW.WEBER.COM®19+AAA +AAA +AAA a23- 1S-440S-640- 2- 2S-440S-640- 4S-640The Weber Grill Out™ Handle Light has a “Tilt Sensor”: Lid up - ON / Li
2WWW.WEBER.COM®LOCATING YOUR GRILLWhen determining a suitable location for your Summit® gas grill installation, give attention to concerns such as exp
20WWW.WEBER.COM®Table10-1Maximum Capacity of Pipe in Cubic Feet of Gas per Hour for Gas Pressures of 0.5 psi or Less and a Pressure Drop of 0.3 InchWa
21WWW.WEBER.COM®21GAS LINE PIPING• Refer to the piping chart at the bottom of previous page.• The corrugated gas line from the manifold is 58 inches
22WWW.WEBER.COM®OPERATING WARNING: Only use the Weber® Tank Enclosure Kit outdoors in a well-ventilated area. Do not use in a garage, building, bree
23WWW.WEBER.COM®23LOCATING YOUR LP TANK ENCLOSURE KITWhen determining a suitable location for your LP Tank Enclosure Kit installation, give attention
24WWW.WEBER.COM®48412422PARTS LIST2Hose and regulator - 1Tank stand - 1Tank stand base - 1Tank Scale - 11/4-20 nut - 6Nylon washer - 121/4-20 x 1/2” b
25WWW.WEBER.COM®25MOUNTING THE LP TANK BRACKETMount the LP tank bracket to the right hand side of the enclosure opening using non corrosive hardware.
26WWW.WEBER.COM®ABCDEiiiiiiivvCONNECT GAS SUPPLYA 58 inch (1,473.2 mm) corrugated gas line is supplied with the grill. This line needs to pass throug
27WWW.WEBER.COM®27VENTILATIONWARNING: Air holes must be provided in the structure at the top and bottom to provide ventilation in the event of a gas
©2007 The following trademarks are registered in the name of Weber-Stephen Products Co., an Illinois corporation, located at 200 East Daniels Road, Pa
3WWW.WEBER.COM®316785324acdb11132bGENERAL CONSTRUCTION DETAILSSummit® Built-In unit and all other accessory units should be on site before constructio
4WWW.WEBER.COM®ORS-440S-640Lid - 1Cookbox - 1Lid - 1Cookbox - 1Front Frame Rail - 1Rear Frame Rail - 1Rear Panel Assembly - 1Bottom Shelf - 1Left Doo
5WWW.WEBER.COM®5S-440S-640S-440S-640Flavorizer® Bars- 8- 12Stainless Steel Cooking Grates- 2- 3Collection Tray - 1Catch-Pan Holder - 1Catch-Pan - 1Dis
6WWW.WEBER.COM®1122312Arrow stickers on Frame Rail (1) and Left Side Panel (2) should point toward each other (shown above). Door Stop Bracket (3) sh
7WWW.WEBER.COM®73 ATTENTION! Do not fully tighten screws. Clips should slide freely when installed.4ASSEMBLY
8WWW.WEBER.COM®56BackASSEMBLY
9WWW.WEBER.COM®97ASSEMBLY
Comments to this Manuals