DANGERIf you smell gas: 1. Shut off gas to the appliance.2. Extinguish any open fl ames.3. Open lid4. If odor continues, keep away from the applia
10GAS INSTRUCTIONSREINSTALL CONTROL PANELParts required: control panel, screws, and burner control knobs.Place the control panel back onto the control
11GAS INSTRUCTIONSREFILLING THE LIQUID PROPANE CYLINDERWe recommend that you refi ll the LP cylinder before it is completely empty.Removal of the LP cy
12GAS INSTRUCTIONSDOT 4BA240 00/05(1)(2)• Air must be removed from a new LP cylinder before the initial fi lling. Your LP dealer is equipped to do thi
13OPERATING INSTRUCTIONSGRILLING METHODSNOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual.You can adjust th
14INDIRECT COOKINGThe Indirect Method is similar to roasting, but with the added benefi ts of that grilled texture, fl avor, and appearance you can’t ge
1517264,5,823OPERATING INSTRUCTIONSLIGHTINGSummary lighting instructions are on the control panel. DANGERFailure to open the lid while igniting the b
16OPERATING INSTRUCTIONS DANGERWhen the “excess gas fl ow control” feature is activated, a small amount of gas is still fl owing to the burners. After
17 DANGERWhen the “excess gas fl ow control” feature is activated, a small amount of gas is still fl owing to the burners. After turning OFF the cylind
18OPERATING INSTRUCTIONSSIDE BURNER LIGHTING INSTRUCTIONS DANGERFailure to open the lid while igniting the side burner, or not waiting 5 minutes to a
19OPERATING INSTRUCTIONSUSING THE SMOKERThe smoker uses presoaked wood chips. For best results with faster cooking foods like steaks, burgers and chop
2DANGERS AND WARNINGSDANGERFailure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury
20OPERATING INSTRUCTIONSLIGHTING THE SMOKER BURNER WARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose
21OPERATING INSTRUCTIONS5) Turn the cylinder on by turning the cylinder valve counterclockwise.WARNING: Do not lean over the open grill while lighti
22WARNING: The burner control knobs must be in the OFF position before turning on the liquid propane cylinder tank valve. If they are not in the OFF
23OPERATING INSTRUCTIONSROTISSERIE ASSEMBLYParts required: rotisserie motor bracket(1), rotisserie motor(1), rotisserie shaft(1), spit forks(4) and fo
24OPERATING INSTRUCTIONSUSING THE ROTISSERIENote - Before using your rotisserie, measure your food at the widest point. If it exceeds 9 1/2” (241.8mm)
25OPERATING INSTRUCTIONSLIGHTING THE ROTISSERIE BURNERATTENTION: READ BEFORELIGHTING ROTISSERIE BURNERAfter a period of non-use, before lighting the
26OPERATING INSTRUCTIONS3) Make sure all burner control knobs are turned OFF. (Push control knob down and turn clockwise to ensure that it is in the
27OPERATING INSTRUCTIONSMANUALLY LIGHTING THE ROTISSERIE BURNERATTENTION: READ BEFORELIGHTING ROTISSERIE BURNERAfter a period of non-use, before ligh
28OPERATING INSTRUCTIONSWARNING: The burner control knobs must be in the OFF position before turning on the liquid propane cylinder tank valve. If th
29MAIN AND SMOKER TROUBLESHOOTINGPROBLEM CHECK CUREBurners burn with a yellow or orange fl ame, in conjunction with the smell of gas.Inspect Spider / I
3WARRANTYWeber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber® gas grill that it will be free of defects in mate
30SIDE BURNER TROUBLESHOOTINGSIDE BURNER MAINTENANCEWARNING: All gas controls and supply valves should be in the OFF position.Make sure black wire i
31PROBLEM CHECK CUREBurner does not light.Did you hold the burner control knob down and hold down for 20 seconds until after burner ignited?Try to rel
32WEBER® SPIDER /INSECT SCREENSYour Weber® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nes
33MAIN BURNER FLAME PATTERNThe Weber® gas barbecue burners have been factory set for the correct air and gas mixture. The correct fl ame pattern is sho
34MAINTENANCE9. Disconnect the Thermocouple from the IR Burner valve.(a )(a(b )(b )10. Remove screws from the manifold assembly: (a) Locate the scre
3512. Lift and twist the burner assembly slightly, to separate the Crossover® tube (a) from the burners (b). (a)(b)(b)13. Remove the Crossover® tube
36(1 )(2 )CROSSOVER® IGNITION SYSTEM OPERATIONSIf the Crossover® ignition system fails to ignite the LEFT burner in a burner set, light the LEFT burne
4GENERAL INSTRUCTIONSYour Weber® gas barbecue is a portable outdoor cooking appliance. With the Weber® gas barbecue you can grill, barbecue, roast and
5GENERAL INSTRUCTIONSCLEANING WARNING: Turn your Weber® gas barbecue OFF and wait for it to cool before cleaning. CAUTION: Do not clean your Flavori
6GAS INSTRUCTIONSIMPORTANT LP CYLINDER INFORMATIONFailure to follow these DANGER statements exactly may result in a fi re causing death or serious inju
7GAS INSTRUCTIONSNote: This connection tightens clockwise and will not allow gas to fl ow unless the connection is tight. The connection requires tight
8GAS INSTRUCTIONSPut your fi ngers under the front edge of the control panel and lift off.Completely remove the control panel (4) from the cooking box
9(8)(2)(4)(6)(7)(1)(3)GAS INSTRUCTIONS(5)(3)(2)(1)(4)Check: 1) Hose connection.2) Gas line to manifold connections. WARNING: If there is a leak at c
Comments to this Manuals