Weber 55024 User Manual

barbecue operation. Do this even if thebarbecue was dealer-assembled.NOTICE TO INSTALLER: These instruc-tions must be left with the owner and theowner

A-101/2 inch bolts (1/4 x 20 x 1/2 inch bolts) - 4Nylon Washers - 4Left Work Surface - 1Right Work Surface with Side Burner - 112 Foot Hose - 1Flavori

B-1Assembly InstructionsB053.a(1) (2)(1)Install the slide out bottom trayYou will need: the slide out bottom tray(1), catch panholder(2), catch pan an

B-2Installing the warming rackYou will need: warming rack.Set the warming rack into the slots at the rear of thecooking box.Installing the Warm-Up™ Ba

C-1Check that all burner valves are offYou will need: burner control knobs.Valves are shipped in the OFF position, but you shouldcheck to be sure that

C-2Install Gas SupplyGeneral Specifications for PipingNote - Contact your local municipality for buildingcodes regulating outdoor gas barbecueinstalla

C-3(1)(2)Check for gas leaks DANGERDo not use an open flame to check for gasleaks. Be sure there are no sparks or openflames in the area while you ch

C-4Reinstall control panel (after checking for gasleaks)(1) Set the control panel in place over both sides ofthe frame. Hold the crossover ignition bu

D-1LightingSummary lighting instructions are on the control panel. DANGERFailure to open the lid while igniting thebarbecue’s burners, or not waiting

D-2To ExtinguishPush down and turn each burner control knobclockwise to the OFF position. Turn gas supplyOFF at the source.Manual Lighting DANGERFail

D-3Lighting the Side BurnerThe side burner has a separate ignition system fromthe main cooking box. DANGERFailure to open the lid while igniting the

A-2 DANGERFailure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manualmay result in serious bodily injury or death, or in a

D-4Cooking WARNING: Do not move the Weber Gas Barbe-cue when operating or while barbecue is hot.You can adjust the FRONT and BACK burners asdesired.

D-5Annual MaintenanceAfter a period of nonuse, we recommend that youperform the following maintenance procedures for yoursafety. WARNING: Check the h

D-6General MaintenanceWeber Spider Stopper™ GuardsYour Weber Gas Barbecue, as well as any outdoor gasappliance, is a target for spiders and other inse

D-7(1)(1)(1)(2) (1) Replacing Main Burners1) Your Weber Gas Barbecue must be OFF and cool.2) Turn gas OFF at source.3) To remove control panel: take o

D-8Crossover® Ignition System OperationsIf the Crossover Ignition System fails to ignite the Leftburner, light the Left burner with a match. If the Le

D-9TroubleshootingProblem Check CureBurners burn with a yellow ororange flame, in conjunction withthe smell of gas.Inspect Weber Spider StopperGuards

D-10Side Burner TroubleshootingProblem Check CureSide Burner does not light.Flame is low in HIGH position.Flame is very yellow inconjunction with the

A-3Weber-Stephen Products Co. (Weber) hereby warrantsto the ORIGINAL PURCHASER of this Weber Gas Grillthat it will be free of defects in material and

A-4Danger & Warnings ... A-2Warranty...

A-5General InstructionsYour Weber Gas Barbecue is a portable outdoorcooking appliance. With the Weber Gas Barbecue youcan grill, barbecue, roast and b

A-643421916414018Genesis Gold-C NG123456789101112131618171920211415232425262729263031323334353637383953555657585944454647484950395152282254

A-71. Hair Pin Cotter2. Hinge Pin3. Left Endcap4. Shroud5. 1/4-20 x 1 1/4 inch bolt6. Handle lock7. Handle8. Warm-Up™ Basket9. Warming Rack10. Cooking

A-8© 1999 Weber-Stephen Products Co., Weber, the silhouette, and the kettle configuration are registered trademarksof Weber-Stephen Products Co.,

A-9Remove Packaging from GrillRemove all tape from packaging. Remove bottom rackfrom top of packaging. Remove outer box. Pull outbottom tray from cook